News
-
420TPH Natural Gas Boiler Steam Drum Is Hoisted in Position
Steam Drum is the most important part of one steam boiler. It is a pressure vessel of water/steam at the top of water tubes. The steam drum stores the saturated steam and serves as a separator for steam/water mixture. The steam drum is used for the following: 1. To mix the remaining saturated wat...Read more -
Introduction to the CFB Boiler Component
CFB boiler component mainly includes drum, water cooling system, superheater, economizer, air preheater, combustion system and refeeding system. This passage will further introduce each component in detail. 1. Drum, internals and accessory part (1) Drum: inner diameter is φ1600 mm, thickness is 4...Read more -
Renovation of one 75TPH Gas Boiler
75TPH Gas Boiler is one set gas steam boiler current used in a petrochemical company in Xinjiang Province. However, due to the improvement of production capacity, the steam amount is insufficient. Based on the principle of saving resource and reducing cost, we decide to make renovation on it. The...Read more -
130TPH CFB Boiler Installation in Anhui Province
130TPH CFB Boiler is another popular coal CFB boiler model in China besides 75TPH CFB Boiler. CFB boiler can burn coal, corn cob, corn straw, rice husk, bagasse, coffee grounds, tobacco stem, herb residue, papermaking waste. Steam boiler manufacturer Taishan Group won a 2*130TPH CFB Boiler projec...Read more -
CFB Boiler Coking Preventive Measures
CFB boiler coking will increase rapidly once occurs, and the coke lump will grow faster and faster. Therefore, prevention of CFB boiler coking and early detection and removal of coking are the principles that operators must master. 1. Ensure good fluidization condition and prevent bed material de...Read more -
Boiler Slagging Hazard
Boiler Slagging Hazard is very serious and dangerous. This passage will discuss the boiler slagging hazard in the following several aspects. 1. Boiler slagging will cause overhigh steam temperature. When a large area of furnace is coking, the heat absorption will be greatly reduced, and the flue ...Read more -
Coal Chain Grate Boiler Delivered to Cambodia
Coal Chain Grate Boiler is the most common coal fired boiler, and the combustion equipment is chain grate. In June 2021, coal fired boiler manufacturer Taishan Group delivered one SZL25-2.0-AII coal steam boiler to Cart Tire (CAMBODIA). Coal Chain Grate Boiler Parameter Rated capacity: 25t/h Rate...Read more -
Cause of Boiler Slagging
Boiler Slagging has many causes, and the most important ones are as follows. 1. The impact from coal type The cause of boiler slagging has a direct relationship with coal type. If coal is of poor quality and large ash content, it is easy to form coking. 2. The impact from pulverized coal quality ...Read more -
What Is Boiler Coking
Boiler Coking is the accumulated block formed by local fuel accumulation at burner nozzle, fuel bed or heating surface. It is common for coal fired boiler or oil boiler, under the circumstance of high temperature and less oxygen. In general, the ash particles are cooled together with the flue gas...Read more -
Design of Small Capacity High Pressure Gas Boiler
High Pressure Gas Boiler is a single drum natural circulation boiler. The whole gas steam boiler is in three parts. The lower part is the body heating surface. The left side of upper part is fin tube economizer, and right side is drum supported by steel frame. The front wall is burner, and rear w...Read more -
Development of 70MW Coal Water Slurry Boiler
Coal Water Slurry Boiler is one type of CFB boiler burning coal water slurry. CWS (coal water slurry) is a new type of coal-based fluid clean and environmentally friendly fuel. It not only retains the combustion characteristics of coal, but has the characteristics of liquid combustion similar to ...Read more -
Design of Gas Condensing Boiler
Gas condensing boiler is a steam boiler that condenses the vapor in the flue gas into water by condenser. It recovers the latent heat released during condensation process, and reuses such heat to achieve 100% or above thermal efficiency. The flue gas temperature of conventional gas fired boilers ...Read more